Commercial Sink Drain Installation

An air break shall be provided between the indirect waste pipe and the trap seal of the waste receptor or standpipe.

Commercial sink drain installation.

Begin by measuring the width length and depth of the sink. The drain are clean. 6 802 2 1 air gap. In this video the old pipes are cut out and properl.

Make sure the drain is perfectly flush with the bottom surface of the sink before you continue. After you have installed your new triple sink you may want to consider how to plumb it. Moen 22036 3 1 2 inch kitchen sink stainless steel basket strainer with drain assembly stainless. The air break is not to be used for fixtures and equipment.

4 5 out of 5 stars 30. You ll need to disconnect the drain pipe and remove the existing strainer if you haven t already. Tighten the sink flange securely with a sink flange tool or similar. Drains for equipment are sometimes located when the floor is poured or block outs can be left for later installation.

To install a kitchen sink drain you ll need a drain assembly kit that fits your sink pliers a basket wrench plumber s putty and a brass tailpiece to attach the basket strainer to the main drainpipe. Measure the area where the sink installation is going. Get it as soon as thu oct 1. Apply firm pressure all around the top of the flange to seat it securely in its bed of putty.

The commercial kitchen however provides a more exotic array of fixtures and equipment such as preparation and triple compartment sinks large dishwashers food waste grinders and disposals hose sprays soda dispensing systems wash down hoods icemakers and. Before tightening position the waste drain handle to the desired location. The pipes had a few attempted repairs in the past. Install the sink flange thru the sink drain opening and screw it into the waste drain assembly below.

Consult with your local inspector or plumbing contractor to determine what local codes require. If the construction of the kitchen is new the area of the sink should have already been designated on the plan of the kitchen floor. A sped up video of repairing commercial sink plumbing. The air gap between the indirect waste pipe and the flood level rim of the waste receptor shall be a minimum of twice the effective opening of the indirect waste pipe.

Triple sinks do provide a challenge but with the right parts and a bit of plumbing experience the job can be done. 8 1 2 inch square floor sink commercial drain cover strainer basket with 3 16 inch holes for restaurant use. Insert the bottom of the drain into the open drain hole.